PICTURES OF CLUTCH
10-07-2008, 01:41 PM
#2
Senior Member
Join Date: May 2007
Location: easton,
PA
Posts: 631
Likes: 0
Received 0 Likes
on
0 Posts
RE: PICTURES OF CLUTCH
Looks to me like it's over heating and causing stress fractures. Is ur drive train binding up at all? Maybe a broken spring is making it slip making all that heat. Could even be the mess is to tight...
10-07-2008, 02:39 PM
#3
Thread Starter
My Feedback: (2)
Join Date: Aug 2002
Location: ballard, WV
Posts: 279
Likes: 0
Received 0 Likes
on
0 Posts
RE: PICTURES OF CLUTCH
no !!!!!!!!! everthing moves freely... the truck seems to run fine... other than being on a rebuilt motor and not shifter it seems to do fine
10-07-2008, 04:25 PM
#4
RE: PICTURES OF CLUTCH
When you change the Clutchbell do you change the pinions too??
And have you had the clutch shoes off since you owned this truck??
Will also need a CLEAR picture of the Clutch Pack too, looking straight on to it
I'm pretty sure what caused that, but we will need to rule out other things first
And have you had the clutch shoes off since you owned this truck??
Will also need a CLEAR picture of the Clutch Pack too, looking straight on to it
I'm pretty sure what caused that, but we will need to rule out other things first
10-08-2008, 06:42 AM
#8
Thread Starter
My Feedback: (2)
Join Date: Aug 2002
Location: ballard, WV
Posts: 279
Likes: 0
Received 0 Likes
on
0 Posts
RE: PICTURES OF CLUTCH
YES I CHANGED THE PINIONS WITH EACH CLTCH BELL AND YES ILL GET PICS TONITE OF THE CLUTCH PACK... SORRY ABOUT THE CAPS I AM AT WORK .....
10-08-2008, 09:42 AM
#10
Thread Starter
My Feedback: (2)
Join Date: Aug 2002
Location: ballard, WV
Posts: 279
Likes: 0
Received 0 Likes
on
0 Posts
RE: PICTURES OF CLUTCH
no the clutches i have been buying come complete with the gears... the very first one i bought from cen didnt but the gears came right off the best i can remeber
10-08-2008, 02:18 PM
#13
Thread Starter
My Feedback: (2)
Join Date: Aug 2002
Location: ballard, WV
Posts: 279
Likes: 0
Received 0 Likes
on
0 Posts
RE: PICTURES OF CLUTCH
well i will have to remove the eng again... but i will for you i dont think they r backwards because i look at the book ... but i will be back with some pics in moring
10-13-2008, 12:24 PM
#18
RE: PICTURES OF CLUTCH
ok Jamie, without seeing the old shoes and the pics are not the clearest, I can say I dont see anything obvious. I was hoping to seer the old shoes, but maybe you can tell me, did they seem to have the exact same wear patterns??
10-13-2008, 01:36 PM
#19
Thread Starter
My Feedback: (2)
Join Date: Aug 2002
Location: ballard, WV
Posts: 279
Likes: 0
Received 0 Likes
on
0 Posts
RE: PICTURES OF CLUTCH
yes they did seem to look the same as new ones ill have a pic of them tomorrow .. i havent drove the truck with this clutch bell on it hoping you could tell me something ??????/
10-13-2008, 02:49 PM
#22
RE: PICTURES OF CLUTCH
Your not, I think your flywheel might drilled just a bit off center, so the pins are not quite centered properly. So here it what I suggest, order a new flywheel from eBay, install it with a new set of shoes and springs, then run it like normal and pay close attention to the clutchbell to see if it gets hot. I have seen this happen 2 other times with 2 other clients.
10-14-2008, 02:07 PM
#23
Thread Starter
My Feedback: (2)
Join Date: Aug 2002
Location: ballard, WV
Posts: 279
Likes: 0
Received 0 Likes
on
0 Posts
RE: PICTURES OF CLUTCH
dogman i am going to try this... and i want to ty for your effort.. i am truly sorry for the way i acted at the first.. you r truly a asset to this forum.. and i want to thankyou again for the compassion you show... ty and i will try this and i will be back to let you know the outcome ty
10-16-2008, 12:08 PM
#25
RE: PICTURES OF CLUTCH
Sounds good Jamie!! Just keep an eye on her and post back your findings.
And No Problem, thats what we are all here for, to help each other out, when the answers aren't right in front of us.
Play hard!!
And No Problem, thats what we are all here for, to help each other out, when the answers aren't right in front of us.
Play hard!!